Dometic VN 780 Instrukcja Użytkownika

ENGLISHDometic Environmental CorporationRev. 20071204L-2485REMOTE AUXILIARY AIR CONDITIONINGAND AIR DISTRIBUTION SYSTEMS FOR VOLVO L-5 CHASSISINSTALLA

ENGLISHVolvo L-5 A/C - Air Distribution System10Locate the V4 RND BLACK 4" grill. Using two cable ties, secure the vanes so that they will not tu

ENGLISH11Volvo L-5 A/C - Air Distribution SystemFigure 10. Preparing to install grills in footwell cover.Figure 11. Location of cut out for ductwork.

ENGLISHVolvo L-5 A/C - Air Distribution System12Figure 12a. Template for 4" duct for 10K unit05.32.00Cut with 3.5"holesawCut with reciproca

ENGLISH13Volvo L-5 A/C - Air Distribution System3.5000.4Drill with 4"hole sawCut with reciprocating sawFigure 12b. Template for 6" duct for

ENGLISHVolvo L-5 A/C - Air Distribution System14Installing the Plenum on the Front of the CHEBUsing a ¼" nutdriver, remove the plastic 5" or

ENGLISH15Volvo L-5 A/C - Air Distribution System• One inboard on the CHEB at the corner nearest the rear of the truck• One on the front, outboard• One

ENGLISHVolvo L-5 A/C - Air Distribution System16Be sure to get the face and the threads. Hand tighten the quick connect, making sure they thread corre

ENGLISH17Volvo L-5 A/C - Air Distribution SystemFigure 16. Condenser installed on mounting plate.INSTALLING THE CONDENSERThe Dometic condenser may be

ENGLISHVolvo L-5 A/C - Air Distribution System18ROUTING THE REFRIGERANT LINES AND CONDENSER POWER CABLEThe refrigerant lines will pass over the exhaus

ENGLISH19Volvo L-5 A/C - Air Distribution SystemFigure 17. Heat shield installed.Figure 18. Routing of refrigerent lines

COPYRIGHT © 2007 Dometic Corporation, All Rights Reserved.No part of this publication may be reproduced, translated, stored in a retrieval

ENGLISHVolvo L-5 A/C - Air Distribution System20Figure 20. Routing of refrigerant lines.TESTING THE INSTALLATION Supply power to the power distri

Dometic Environmental CorporationP.O. BOX 15299 I RICHMOND, VA 23227 USA I 804-746-1313 I FAX 804-746-7248www.DometicTruck.com I [email protected]

ENGLISH3Volvo L-5 A/C - Air Distribution SystemDOMETIC TRUCK REMOTE AUXILIARY AC SYSTEMS FOR VOLVO L-5 CHASSISCONTENTSINTRODUCTION 4INSTALLING THE CO

ENGLISHVolvo L-5 A/C - Air Distribution System4The instructions that follow represent years of development of parts and procedures that make the syste

ENGLISH5Volvo L-5 A/C - Air Distribution SystemMounting the Power Logic BoxThe Power Logic Box (PLB) will be mounted under the rear, center po

ENGLISHVolvo L-5 A/C - Air Distribution System6onto the machine screws. Secure the box with four nuts and lockwashers. KEPS nuts are easiest to

ENGLISH7Volvo L-5 A/C - Air Distribution SystemINSTALLING THE RETURN AIR VENTThe supplied return air vent should be installed under the bunk in the si

ENGLISHVolvo L-5 A/C - Air Distribution System8Figure 5. Location of installed ductworkFigure 6. Footwell removed

ENGLISH9Volvo L-5 A/C - Air Distribution SystemFigure 7. Removal of sensor.Figure 8a. Four inch hole cut in Volvo duct. Figure 8b. Installation of gr